Carcass Characteristics and Qualitative Attributes of Pork from Immunocastrated Animals

Article information

Asian-Australas J Anim Sci. 2013;26(11):1630-1636
Federal University of Grande Dourados, College of Agrarian Sciences, Dourados, MS, Brazil
*Corresponding Author: Fabiana Ribeiro Caldara. Tel: +55-67-81188114, E-mail: fabianacaldara@ufgd.edu.br
Received 2013 March 19; Accepted 2013 July 03; Revised 2013 July 16.

Abstract

An investigation was carried out to assess the carcass characteristics and meat quality aspects of immunocastrated male pigs of medium genetic potential for lean meat deposition in carcass (53 to 55%). When the crossbred Large White x Landrace pigs (n = 45) were 70 days old, they were distributed in a totally randomized design in three treatments (castrated males, females and immunocastrated males) with three replicates of five animals. The pigs were slaughtered when they were 140 days old. Carcass temperature and pH were recorded twice, at 45 min and 24 h after slaughter. The carcasses were evaluated for hot and cold carcass yield, commercial cuts yield, length and depth, back fat thickness, loin eye area and lean meat percentage. The Longissimus dorsi muscle was extracted for analysis of color (L*, a*, b*), exudate loss, cooking loss and centesimal and sensorial analysis of the meat. There were no significant differences for the evaluated parameters between castrated males, immunocastrated males and females, except for backfat thickness between the 7th and 8th thoracic vertebra and the point P2 (lower for immunocastrated males) and carcass temperature at 45 min post slaughter (higher in immunocastrated males), however, this did not interfer with the rate of pH decrease post mortem and the meat quality. The results from this research did not indicate a benefit of immunocastration on carcass characteristics of pigs of medium genetic potential for lean meat deposition in carcass, when compared to surgical castration.

INTRODUCTION

In today’s swine production, a large part of the slaughtered herd is of castrated males. The gonadectomy in young pigs is a usual practice in swine production worldwide. It is estimated that near 100 million piglets are castrated annually just in the European Union (Thun et al., 2006). However, castrated males present reduced feed efficiency and nitrogen retention and also less lean meat to fat (Pauly et al., 2009), which makes the production more expensive when compared to non-castrated males. Another significant aspect is that surgical castration decreases a piglets production performance (Prunier et al., 2006). As castration is a painful and stressing procedure it has been abolished in some countries (Bauer et al., 2008). These negative aspects of the surgery procedure have influenced its gradual abandonment; however, the carcass odor of non-castrated pigs remains an issue.

It is clear that alternatives to the surgical castration of pigs must be used, but they need to be practical, economically feasible, do not cause adverse impacts to animal performance and meet consumer requirements and principles of animal welfare. The immunological castration using anti-GnRH is a procedure which can replace surgical castration of male pigs, as it has proved effective in reducing the concentration of the main hormones responsible for causing the carcass odor (Dunshea et al., 2001). It also allows the animals to have longer satisfactory performance and carcass characteristics than those of non-castrated males, generating positive productive impact on the pig production. Its application, however, should be studied with care, as there are issues related to the economic viability and consumer acceptance of pork from treated pigs. Many studies support the effectiveness of this management; which is used in animals of high genetic potential (pigs of commercial lines genetically improved, with potential for lean meat deposition in carcass greater than 56%) (Pauly et al., 2009; Gispert et al., 2010; Skrlep et al., 2010). However, these benefits are not automatically extended to pigs with lower performance.

This research aimed to study the effects of immunocastration of pigs of medium genetic potential in the parameters of carcass and meat quality.

MATERIAL AND METHODS

Local, experimental design, diets and animals management

The study was conducted at the Swine Experimental Sector, Federal University of Grande Dourados, Agrarian Sciences College, MS, Brazil. A total of 45 Landrace× Large White crossbred pigs were used. They were 70 days old, and with an average weight of 25.2±2.8 kg, consisting of 15 females and 30 males that were distributed in a fully randomized experimental design with three treatments, three repetitions with 15 pigs per treatment. The treatments were T1 (females), T2 (surgically castrated males), and T3 (immunocastrated males). All pigs were in the same rearing conditions, in open sided pens with semi-automated feeders and nipple drinkers, concrete floor, and a herd density of 0.8 m2/ animal.

The trial period was 70 d, divided into two phases growing (70 to110 d) and finishing (111 to 140 d). The experimental fodder was formulated using corn and soybean and supplemented with minerals and vitamins (Rostagno et al., 2011). The management requirements for boars during growth and females in the finishing phase were met. Fodder and water were provided ad libitum throughout the trial.

The castrated animals were subjected to orchiectomy procedure on the seventh day of life. Immunocastrated animals received two dosages of Vivax, which is a vaccine based on a synthetic analogue of GnRH coupled to a large carrier protein. It was applied subcutaneous and the first dosage was given at 60 d before slaughter (pigs were 80 days old) while the following at 30 days before slaughter (pigs were 110 days old).

Carcass quality measurements

At the end of the experimental period, the animals were put on a fast from solid feed for 18 h; they were then weighted and slaughtered and their performance and carcass characteristics and meat quality were evaluated. Immediately after stunning by electronarcosis, the animals were bled via jugular incision and subjected to scalding, eviscerated and divided into two half-carcasses. At 45 min after slaughter pH and temperature of carcasses were recorded using pH meter coupled to a penetration probe, inserted into the center of the Longissimus dorsi muscle in the left half-carcass between the 12th and 13th thoracic vertebra. The procedure was repeated 24 h after slaughter.

The carcasses were weighed in order to obtain the hot carcass weight (HCW). The carcass was considered with the head, tail and feet. It was chilled in the refrigerator for 24 h at ±2°C temperature, and re-weighed to determine the weight of the cooled carcass (CCW). Carcass yield (%) was calculated by the carcass weight (hot and cold)×100, divided by the live weight at slaughter as described by Bridi and Silva (2007). The length and depth of carcasses were recorded using the Brazilian method for carcass classifying (BMCC). The backfat thickness between the 7th and 8th thoracic vertebra, between the 3rd and 4th lumbar vertebra, and at the point P2 was measured using calipers. The loin eye area was recorded according to the methodology proposed by Boggs and Merkel (1993), which consisted of the section between the 10th and 11th ribs of the left half carcass, where a cross section of the Longissimus dorsi was exposed. A decal was made using transparent plastic in order to get the shape of that muscle. The determination of the area was done with the aid of a plastic matrix formed by a square with an area of 0.25 cm2. The left half was dissected into primary cuts (ham with bone and without skin, shoulder boneless and skinless, rack and blade shoulder) for determining the yield of each cut (weight of the component in relation to the chilled carcass weight× 100). The lean meat yield was calculated as the ratio between the weight of lean meat (ham with bone, blade shoulder, boneless shoulder and boneless rack) and the standard carcass (half carcass weight minus the weight of the head, feet, tail and lard) as suggested by Rose (2001).

Meat quality measurements

The qualitative measurements in the Longissimus dorsi muscle were done using the methodologies described as follows:

  • Meat color: aiming the muscle oxygenation each sample remained exposed to the air for 15 min. After this period, the meat was slightly dried with paper towels and the color was measured using a portable color meter (Minolta CR 410). The components L* (lightness), a* (red-green) and b* (yellow-blue) were shown in the color system CIELAB and assessed at three different points of the muscle surface using illuminant D65 and observational angle of 10°.

  • Exudate loss (EL): samples in steak form of 2.5 cm width were prepared and the external fat removed, and weighted in a semi-analytic scale. They were kept as a simulated retail sale on a 45° angle of inclination shelf, in trays covered with a plastic film at 4±1°C during 48 h. After this period, the exudate was discharged, and the samples were weighted again. The EL was expressed as a percentage of the initial weight.

  • Weight loss by cooking (WLC): samples in steak form of 2.5 cm width were prepared and the external fat was removed and weighed in a semi-analytic scale, and roasted without the addition of condiments. The oven was preheated to the temperature of 170°C. The internal temperature of the samples was monitored during cooking using sensors tied to a digital thermometer. When samples’ internal temperature reached 80°C they were taken from oven and cooled at room temperature, and then they were weighted. WLC was expressed in percentage of water lost in relation to the original sample weight.

  • Shear force (SF): three cylinder sub-samples were removed from each WLC sample, parallel to the muscle fiber orientation. Sub-samples were placed with the fiber oriented perpendicular to the Warner-Bratzler lamina as described by Froning et al. (1978). The average of three repetitions and the value of shear force for each sub-sample were used for assessing the tenderness of the meat.

  • Sensorial analysis: samples in steak form of 2.5 cm width were roasted without the addition of condiments in a pre-heated oven at the temperature of 170°C until the internal temperature reached 80°C. Sensory evaluations were performed for meat tenderness, juiciness, flavor and odor, based on a nine-point scale, using a non-trained panel of forty tasters, according to Kauffman et al. (1993). Later on with the same testers’ team the Triangle Test (ABNT, 1993) was performed in which, in each round of tests three samples of meat were served concurrently to the tester, being two equal and one different. The testers were asked to try the samples and mark the different sample in question regarding flavor. Testers were asked their opinion of intent to buy and preference in relation to the evaluated products.

  • Proximate analysis: five samples of each treatment were lyophilized for determining the amount of dry matter. After the assessment of the moisture, the samples were used for determining the raw protein content, ether extract and mineral matter (BRASIL, 1981).

Statistical analysis

ANOVA was applied to mean values using the SAS 9.2 computer package (SAS, 2001), applying the general linear model (GLM). Means were compared using Tukey test considering 5% level of significance, when test F was significant for all variables. For the pork sensorial characteristics, the Kruskal-Wallis test was applied as suggested by Sampaio (2002).

RESULTS AND DISCUSSION

The carcass pH at 45 min and 24 h after slaughter did not differ between treatments. However, immunocastrated pigs presented a higher carcass temperature at 45 min after slaughter (Table 1). After 24 h of slaughter castrated pigs presented a higher carcass temperature that may have been related to a thicker subcutaneous fat which served as a thermal isolation retaining the carcass cooling.

Temperature and pH of the carcass of castrated male pigs, immunocastrated, and females at 45 min and 24 h post mortem

There was no evidence of the presence of PSE meat since it presents a pH value of less than 5.8 at 45 min post mortem (Velazco, 2001). Although immunocastrated males had higher carcass temperature at 45 min (about two degrees higher), no association was found between this parameter and accelerated reduction in pH. The final pH is within the range considered normal for pork.

Comparing the quality of meat from castrated males, females and immunocastrated Pauly et al. (2009) and Gyspert et al. (2010) observed no differences in relation to the initial and final pH between different types of pork and the values found by these researchers were close to those obtained in the present experiment. No difference was found (p>0.05) in carcass yield hot or cold, loss during cooling, depth and carcass length, loin eye area, lean meat yield and backfat thickness between the 3rd and 4th lumbar vertebra, between carcasses of pigs immunocastrated, castrated and females. Surgically castrated males had higher backfat thickness between the 7th and 8th thoracic vertebra than females and immunocastrated. Immunologically castrated males presented lower backfat thickness at the point P2 than females and males castrated; however, the amount was not sufficient to provide different percentages of lean meat (Table 2).

Hot carcass yield (HCY), cold carcass yield (CCY), cooling loss (CL), loin eye area (LEA), backfat thickness between the 7th and 8th thoracic vertebra (BT× 7 and 8), backfat thickness between the 3rd and 4th lumbar vertebra (BT× 3 and 4), backfat thickness at point P2 (BT P2), lean meat yield (LMY), length and depth of carcass from male immunocastrated, surgical castrated and female pigs

When evaluating pig carcass characteristics from different genetic groups Guimarães (2007) did not find a difference in hot and cold carcass or in loss to cooling between females and castrated males. Assessing carcass parameters of immunocastrated pigs Moraes et al. (2010) identified the effect of sex on the hot carcass yield, and the females showed higher yield than the immunocastrated pigs; which were superior to castrated males. However, Pauly et al. (2009) found larger values of carcass yield for castrated males (79.5%) than those of immunocastrated (78.3%), values similar to those observed in the present study. Lanferdini et al. (2012) also found cold carcass yield almost 3% higher for surgically castrated males than immunocastrated pigs. According to Rosa et al. (2008) carcass yield may be influenced by age and weight at slaughter. It is higher for females, in the finishing phase I than to castrated males while the opposite occurs in the finishing phase II.

Guimarães et al. (2011) found no difference between barrows and gilts of commercial lines for BT between the 10th and 11th rib, BT in P2 and LEA. The backfat thickness values found by these authors were similar to those found in the present study. These LEA values were higher than those determined by this study. Although that research had pigs with a different slaughter weight (±109 kg compared to this study which used pigs of ±90 kg), which may have been due to the low genetic potential of crossbred Large White× Landrace when compared to animals of commercial strains.

When comparing carcass characteristics of male and immunocastrated pigs Tonietti (2008) observed that the immunocastrated pigs presented higher hot carcass weight, larger amount of meat and lean percentage, greater loin eye area and lower amount of fat than those non-castrated animals. Pauly et al. (2009) also found higher yield of lean meat in immunocastrated males (56.3%) than in castrated males (54.5%), values that were similar to those found in the present study. In contrast, McCauley et al. (2003) reported greater fat deposition in immunocastrated animals than in non-castrated pigs.

No difference was found in the cuts yield from all treatments (p>0.05; Table 3). Assessing the commercial cuts in pig carcasses, Guimarães (2007) noted that females presented higher means for ham yield than castrated males, suggesting that the carcass of sows should be used in the market due to their large cuts yield. Comparing the commercial cuts between male pigs and immunocastrated Lanferdini et al. (2012) found a higher yield of rack in surgically castrated pigs than non-castrated pigs, and greater weight and ham yield for immunocastrated pigs than for non-castrated ones. Tonietti (2008) and Pauly et al. (2009) results suggest that immune castration improved the performance of pigs in relation to males surgically castrated, and also added more meat cuts with higher commercial value, such as ham, rack, belly and shoulder, suggesting that this may represent economic benefit for the meat industry.

Yield (%) of commercial cuts of male immunocastrated, surgical castrated and female pigs

No difference was found in the loss by cooking between the meat of gilt (24.57%), surgical castrated male (26.73%) and immunocastrated pigs (23.65%) (Figure 1). The values found were close to those obtained by Bridi et al. (2006). Pork from castrated pigs presented higher exudate loss (7.32%) than gilts (3.54%) and immunocastrated pigs (Figure 1). The values of exudate loss from pork of the pigs surgically castrated were higher than that reported by Lien et al. (2002) and Kuo and Chu (2003) for regular meat (1.6% and 4.51%, respectively). Loss of exudate occurs as a consequence of the shrinking of the myofibrils in the period post mortem, and it is one of the main factors of quality loss in meat products (Jensen et al., 2003). After the cut of the carcass, the exudate contributes to the total loss of water, and it is influenced by the decline of the pH, the size of the pieces and the time of processing.

Figure 1.

Exudate loss (%) and weight loss by cooking (%) of loin of male immunocastrated, surgical castrated and female pigs. Means followed by different letters in the line differ between them by Tukey test (p≤0.05).

The loss by cooking is due to the shrinking of the myofibrils during the process, and it can vary through time and cooking temperature since high temperatures may cause denaturation of proteins, subcutaneous, intramuscular and inter muscular fat loss. Although current literature (Cronin et al., 2003) indicates that immunocastrated pigs may have their backup of glycogen used quicker than non-castrated pigs, affecting changes in the pH during the conversion of muscle in meat, therefore, affecting pork quality; this was not observed in the present study.

No difference was found (p>0.05) in the values of redness (a*) and yellowness (b*) in the meat of male immunocastrated, surgical castrated and female pigs. Shear force did not differ between the tested pigs. Surgically castrated males presented meat with higher lightness than immunocastrated ones (Table 4).

Lightness (L*), redness (a*), yellowness (a*) and shear force (SF) of the muscle longissimus dorsi of male immunocastrated, surgical castrated and female pigs

The quality of pork and its presentation to the consumer may be affected by several factors. A genetic selection for production of lean meat has resulted in changes, in physical characteristics and muscle metabolism, influencing the visual and organoleptic characteristics of pork and hence the acceptability of the product by consumers. The lightness in color of the meat can be affected by the amount of water present in it. Meats that have reduced water holding capacity reflect light in a dispersed way, making it lighter than normal meat. This could explain the fact that the meat from castrated animals appears paler since its water retention capacity was significantly lower than the other pigs. The American Meat Science Association (America Meat Science Association, 2001) considers the L* values between 49 and 60 within the normal standards of pork quality and the values found in the present study were normal despite the treatments. However, Ramos and Gomide (2007) consider the L* values of normal meat to be in the range between 45 and 53.

Pauly et al. (2009) found no differences in relation to lightness, redness and yellowness when comparing the quality of meat from surgically castrated, non-castrated, and immunocastrated pigs. However, L * values observed by the authors (50.1 to 51.0) were lower than those obtained in the present study. The same authors found that meat from surgically castrated and non-castrated males was more resistant to cut than the meat from immunocastrated meat. A plausible cause for this difference may be the compensatory growth of immunocastrated pigs compared to surgically castrated and non-castrated pigs at the end of the finishing period, followed by an increased proteolytic capacity (reason: calpain:calpastatin) and a high rate of softening. The SF values obtained by these authors were similar to those observed in the present study (3.45 to 3.77). The results of the shear force for the loins of the three treatments may be considered suitable for softness with pork. According to Iversen et al. (1995) the threshold between the softness and hardness of pork, measured through the SF is 6.0 kgf.

The centesimal composition of meat from immunocastrated pigs was not different from that of barrows and gilts (p>0.05; Table 5).

Humidity, crude protein (CP), mineral matter (MM) and ether extract (EE) of the meat of male immunocastrated, surgical castrated and female pigs

Meat odor, visual appearance, tenderness, juiciness and flavor, did not differ (Table 6) between the flesh of animals castrated, immunocastrated and females. On a 7-point hedonic scale, the odor was rated between “liked moderately” and “genuinely liked”. As for the visual appearance, tenderness, juiciness and flavor answers were mostly between “not liked/disliked” or “liked moderately”. There was no difference in the opinion of “purchase intent” that was placed on a 5-point scale between “probably buy” and “maybe/maybe not”.

Sensorial parameters and intention of purchase pork from male immunocastrated, surgical castrated and female pigs

The Triangular test, when three coded samples were given to testers, being two equal (female and surgically castrated male) and one different (immunocastrated pig), the testers were not able to identify the pork from the immunocastrated pig.

Skrlep et al. (2010) found that pigs surgically castrated presented with less frequency and intensity of displeasing odor than of those from immunocastrated pigs. Conversely, it was found that meat from boars presented strong disagreeable odor (92%). Only two samples of pork from immunocastrated pigs were identified as having a strong “boar taint”, despite the fact that the samples from the immunocastrated pigs presented lower androsterone level than the limit detected in laboratory. The efficacy of immunocastration for preventing boar odor in meat has been proved by the reduction of hormone levels (Dunshea et al., 2001; Metz et al., 2002; Turkstra et al., 2002; Jaros et al., 2005; Schmoll et al., 2009), by sensorial study done with consumers (Font I Furnols et al., 2008) as well as by panel testers (Pearce et al., 2008; Font I Furnols et al., 2009).

IMPLICATIONS

Immunocastration can replace surgical castration without change to the qualitative characteristics of the meat. However, the benefits towards the improvement of the carcass are not as promising as in animals with high genetic potential, and immunocastration should be evaluated on its economic feasibility in swine production systems that use animals with low growth potential and carcass meat deposition.

Acknowledgements

The work was supported by the Mato Grosso do Sul State Foundation for the Development of Teaching, Science and Technology (FUNDECT), Brazil.

References

ABNT (Associação Brasileira De Normas Técnicas). 1993. Teste triangular em análise sensorial dos alimentos e bebidas - NBR 12995 São Paulo: ABNT; 1993. p. 5.
AMSA (American Meat Science Association). 2001. Meat Evaluation Handbook American Meat Science Association. Savoy, IL:
Bauer A, Lacorn M, Danowski K, Claus R. 2008;Effects of immunization against GnRH on gonadotropins, the GH-IGF-I-axis and metabolic parameters in barrows. Animal 2:1215–1222.
Boggs DL, Merkel AR. 1993. Live animal carcass evaluation and selection manual 4th edth ed. Dubuque: Kendal/Hunt Pub. Co.
Bonneau M, Enright WJ. 1995;Immunocastration in cattle and pigs. Livest Prod Sci 42:193–200.
BRASIL. Ministério da Agricultura. Secretaria Nacional de Defesa Agropecuária. Laboratório Nacional de Referência Animal. 1981. Portaria n. 001/81, de 07 de outubro de 1981. Métodos analíticos oficiais para controle de produtos de origem animal e seus ingredientes. I. Métodos microbiológicos. II. Métodos físicoquímicos. Brasília.
Bridi AM, Silva CA. 2007. Métodos de Avaliação da Carcaça e da Carne Suína 1th edth ed. Londrina: MIDIOGRAF. 1
Bridi AM, Oliveira AR, Fonseca NAN, Shimokomaki M, Coutinho LL, Silva CA. 2006;Efeito do genótipo halotano, da ractopamina e do sexo do animal na qualidade da carne suína. Rev Bras Zootec 35:2027–2033.
Cronin G, Dunshea FR, Butler KL, Mcauley I, Barnett JL, Hemsworth PH. 2003;The effects of immuno- and surgical-castration on the behaviour and consequently growth of group-housed, male finisher pigs. Appl Anim Behav Sci 81:111–126.
Dunshea FR, Colantoni C, Howard K, McCauley I, Jackson P, Long KA, Lopaticki S, Nugent EA, Simons JA, Walker J, Hennessy DP. 2001;Vaccination of boards with a GnRH vaccine (Improvac) eliminates boar taint and increases growth performance. J Anim Sci 79:2524–2535.
Font I Furnols M, Gispert M, Guerrero L, Velarde A, Tibau J, Soler J, Hortós M, García-Regueir JA, Pérez J, Suárez P, Oliver MA. 2008;Consumer′s sensory acceptability of pork from immunocastrated male pigs. Meat Sci 80:1013–1018.
Font I Furnols M, Gonzalez J, Gispert M, Oliver MA, Hortós M, Pérez J, Suárez P, Guerrero L. 2009;Sensory characterization of meat from pigs vaccinated against gonadotropin releasing factor compared to meat from surgically castrated, entire male and female pigs. Meat Sci 83:438–442.
Froning GW, Babji AS, Mather FB. 1978;The effect of preslaughter temperature, stress, stuggle and anesthetization on color and textural characteristics of turkey muscle. Poult Sci 57:630–633.
Guimarães GG. 2007. Desempenho e características de carcaça suína de dois cruzamentos de linhagens comerciais criados em cama sobreposta. PhD. Thesis, Universidade de Brasília, Faculdade de Agronomia e Medicina Veterinária, Brasília, DF, Brazil.
Guimarães GG, Murata LS, Mcmanus C, Santana AP, Reckziegel GC, Amâncio AS, Filho RMJ, Sobrinho AJF. 2011;Desempenho de suínos de dois cruzamentos de linhagens comerciais criados em cama sobreposta. Arch Zootec 60:11–18.
Gyspert M, Oliver MA, Velarde A, Suarez P, Peréz J, Font I Furnols M. 2010;Carcass and meat quality characteristics of immunocastrated male, surgically castrated male, entire male and female pigs. Meat Sci 85:664–670.
Iversen P, Henckel P, Larsen LM, Monllao S, Moller AJ. 1995;Tenderization of pork as affected by degree of cold-induced shortening. Meat Sci 40:171–181.
Jaros P, Bürgi E, Stärk KDC, Claus R, Hennessy D, Thun R. 2005;Effect of active immunization against GnRH on androstenone concentration, growth performance and carcass quality in intact male pigs. Livest Prod Sci 92:31–38.
Jensen JM, Prestat C, Ryan KJ, Robbins KL, Homco-Ryan CL, Mckeith F, Brewer MS. 2003;Enhancement solution effects on shelf-life, color and sensory characteristics of pork chops during retail display. J Food Qual 26:271–283.
Kauffman RG, Van Laack RL, Russell RL, Pospiec E, Cornelius CA, Suckow CE, Grease ML. 1998;Can pale, soft, exudative pork be prevented by postmortem sodium bicarbonate injection? J Anim Sci 76:3010–3015.
Kuo CC, Chu CY. 2003;Quality characteristics of Chinese sausages made from PSE pork. Meat Sci 64:441–449.
Lanferdini E, Lovatto PA, Melchior R, Klein CC, Broch J, Garcia GG. 2012;Características de carcaça e da carne de suínos machos castrados e imunocastrados alimentados com diferentes níveis nutricionais. Ciência Rural 42:2071–2077.
Lien R, Hunt MC, Anderson S, Kropf DH, Loughin TM, Dikeman ME, Velazco J. 2002;Effects of endpoint temperature on the internal color of pork patties of different myoglobin form, initial cooking state, and quality. J Food Sci 67:1011–1015.
Mccauley I, Watt M, Suster D, Kerton DJ, Oliver WT, Harrell RJ, Dunshea FR. 2003;A GnRF vaccine (Improvac®) and porcine somatotropin (Reporcin®) have synergistic effects upon growth performance in both boars and gilts. Aust J Agric Res 54:11–20.
Metz C, Hohl K, Waidelich S, Drochner SW, Claus R. 2002;Active immunization of boars against GnRH at an early age: consequences for testicular function, boar taint accumulation and N-retention. Livest Prod Sci 74:147–157.
Pauly C, Spring P, O’doherty JV, Ampuero Kragten S, Bee G. 2009;Growth performance, carcass characteristics and meat quality of group-penned surgically castrated, immunocastrated (Improvac®) and entire male pigs and individually penned entire male pigs. Animal 3:1057–1066.
Pearce MC, Baker A, Hughes SI, Nute GR, Wittington FM, Wood JD. 2008. Eating quality of pork loin steaks from light slaughter weight boars vaccinated with Improvac EAAP. Girona, Spain: 26–27. March.
Prunier A, Bonneau M, Von Borell EH, Cinotti S, Gunn M, Fredriksen B, Giersing M, Morton DB, Tuyttens FAM, Velarde A. 2006;A review of the welfare consequences of surgical castration in piglets and evaluation of non-surgical methods. Anim Welfare 15:277–289.
Ramos EM, Gomide LAM. 2007. Avaliação da qualidade de carnes: Fundamentos e Metodologias Viçosa, MG: Ed. UFV.
Rosa AF, Sobral PJA, Lima CG, Gomes JDF. 2001;Determinação das características físico-químicas da carne de suínos em fase de crescimento. Rev. Tec. Carnes, Campinas, SP 3:13–18.
Rosa AF, Gomes JDF, Martelli MR, Sobral PJA, Lima CG. 2008;Qualidade da carne de suínos de três linhagens genéticas comerciais em diferentes pesos de abate. Ciência Rural 38:1394–1401.
Rostagno HS, Albino LFT, Donzele JL, Gomes PC, Oliveira RF, Lopes DC, Ferreira AS, Barreto SLT, Euclides RF. 2011. Tabelas Brasileiras para aves e suínos. Composição de alimentos e exigências nutricionais 3a Edth ed. Viçosa, MG: Universidade Federal de Viçosa.
Sampaio IBM. 2002. Estatística aplicada à experimentação animal 2.edth ed. Belo Horizonte: FEPMVZ.
SAS Institute Inc. 2001. SAS/STAT user’s guide: Version 6 6th edth ed. SAS Institute Inc. Cary, North Carolina:
Schmoll F, Kauffold J, Pfutzner A, Baumgartner J, Brock F, Grodzycki M, Andrews S. 2009;Growth performance and carcass traits of boars raised in germany and either surgically castrated of vaccinated against gonadotropin-releasing hormone. J Swine Health Prod 17:250–255.
Škrlep M, Šegula B, Prevolnik M, Kirbiš A, Fazarinc G, Čandek – Potokar M. 2010;Effect of immunocastration (Improvac®) in fattening pigs II: Carcass traits and meat quality. Slov Vet Res 47:65–72.
Thun R, Gajewski Z, Janett FF. 2006;Castration in male pigs: techniques and animal welfare issues. J Physiol Pharmacol 57:189–194.
Tonietti AP. 2009. Avaliações do desempenho zootécnico, qualidade da carcaça e carne em suíno macho inteiro imunocastrado Ph.D. Thesis, Universidade de São Paulo, Escola Superior de Agricultura Luiz de Queiroz, Piracicaba, SP, Brazil.
Turkstra JA, Zeng XY, Van Diepen JTHM, Jongbloed AW, Oonk HB, van de Wielt DF, Meloen RH. 2002;Performance of male pigs immunized against GnRH is related to the time of onset of biological response. J Anim Sci 80:2953–2959.
Velazco J. 2001;Prevención de PSE en carne de cerdo. Rev Carne Tec 8:28–34.
Zeng XY, Turkstra JA, Jongbloed AW, van Diepen JT, Meloen RH, Oonk HB, Guo DZ, van de Wiel DFM. 2002;Performance and hormone levels of immunocastrated, surgically castrated and intact male pigs fed ad libitum high- and low- energy diets. Livest Prod Sci 77:1–11.

Article information Continued

Figure 1.

Exudate loss (%) and weight loss by cooking (%) of loin of male immunocastrated, surgical castrated and female pigs. Means followed by different letters in the line differ between them by Tukey test (p≤0.05).

Table 1.

Temperature and pH of the carcass of castrated male pigs, immunocastrated, and females at 45 min and 24 h post mortem

Variable Treatment
Castrated Female Immunocastrated
pH 45 min 6.15 6.04 6.01
pH 24 h 5.60 5.71 5.61
T°C 45 min 29.77b 30.54b 32.22a
T°C 24 h 7.45a 5.80b 6.15b

Means followed by different letters in the line differ between them by Tukey test (p<0.05).

Table 2.

Hot carcass yield (HCY), cold carcass yield (CCY), cooling loss (CL), loin eye area (LEA), backfat thickness between the 7th and 8th thoracic vertebra (BT× 7 and 8), backfat thickness between the 3rd and 4th lumbar vertebra (BT× 3 and 4), backfat thickness at point P2 (BT P2), lean meat yield (LMY), length and depth of carcass from male immunocastrated, surgical castrated and female pigs

Variable Treatment
CV (%)
Castrated Female Immunocastrated
HCY (%) 79.85 81.37 80.64 6.20
CCY (%) 77.98 79.45 78.67 4.73
CL (%) 2.35 2.36 2.44 13.47
LEA (cm2) 35.46 34.33 37.74 14.28
BT× 7 and 8 (mm) 26.32a 24.05b 23.29b 23.70
BT× 3 and 4 (mm) 18.31 17.91 17.56 26.74
BT P2 (mm) 14.09a 14.73a 11.16b 19.77
LMY (%) 53.29 53.17 54.82 4.40
Depth (cm) 31.30 31.70 32.40 5.76
Length (cm) 76.70 77.90 75.70 3.64

Means followed by different letters in the line differ between them by Tukey test (p<0.05).

Table 3.

Yield (%) of commercial cuts of male immunocastrated, surgical castrated and female pigs

Cut Treatment
CV (%)
Castrated Female Immunocastrated
Ham 22.87 21.99 23.28 4.71
Shoulder 10.38 10.13 11.12 9.11
Rack 13.12 14.70 13.52 6.84
Blade shoulder 6.92 6.35 6.91 8.81

Table 4.

Lightness (L*), redness (a*), yellowness (a*) and shear force (SF) of the muscle longissimus dorsi of male immunocastrated, surgical castrated and female pigs

Variable Treatment
CV (%)
Castrated Female Immunocastrated
a* 13.47 13.75 14.24 5.06
b* 7.79 7.03 6.87 9.88
L* 60.45a 58.93ab 57.29b 4.63
SF (kgf) 3.63 3.61 4.17 18.66

Means followed by different letters in the line differ between them by Tukey test (p<0.05).

Table 5.

Humidity, crude protein (CP), mineral matter (MM) and ether extract (EE) of the meat of male immunocastrated, surgical castrated and female pigs

Variable Treatment
CV (%)
Castrated Female Immunocastrated
Humidity 80.40 80.50 79.88 0.86
CP 14.75 14.34 14.65 3.68
MM 1.11 1.08 1.06 7.18
EE 3.63 3.98 4.28 20.30

Results expressed in the wet weight basis.

Table 6.

Sensorial parameters and intention of purchase pork from male immunocastrated, surgical castrated and female pigs

Variable Treatment
Castrated Female Immunocastrated
Odor 5.23 5.64 5.29
Visual aspect 4.68 4.64 4.83
Softness 5.08 5.26 4.90
Juiciness 4.78 4.82 4.54
Flavor 4.87 5.09 4.67
Intention of purchase 2.56 2.22 2.35