Cholesterol Removal from Whole Egg by Crosslinked β-Cyclodextrin

Article information

Asian-Australas J Anim Sci. 2014;27(4):537-542
*Corresponding Author: H. S. Kwak. Tel: +82-2-3408-3226, Fax: +82-2-3408-4319, E-mail: kwakhs@sejong.ac.kr
Department of Food Science and Technology, Sejong University, Seoul 143-747, Korea
Received 2013 November 08; Revised 2014 January 21; Accepted 2014 January 14.

Abstract

This study was carried out to optimize cholesterol removal in whole egg using crosslinked β-cyclodextrin (β-CD) and to recycle the β-CD. Various factors for optimizing conditions were concentration of the β-CD, mixing temperature, mixing time, mixing speed and centrifugal speed. In the result of this study, the optimum conditions of cholesterol removal were 25% crosslinked β-CD, 40°C mixing temperature, 30 min mixing time, 1,200 rpm mixing speed and 2,810×g centrifugal speed. The recycling was repeated five times. The cholesterol removal was 92.76% when treated with the optimum conditions. After determining the optimum conditions, the recyclable yields of the crosslinked β-CD ranged from 86.66% to 87.60% in the recycling and the percentage of cholesterol removal was over 80% until third recycling. However, the cholesterol removal efficiency was decreased when the number of repeated recycling was increased. Based on the result of this study, it was concluded that the crosslinked β-CD was efficient for cholesterol removal in whole egg, and recycling is possible for only limited repeating times due to the interaction of the β-CD and egg protein.

INTRODUCTION

Cholesterol is necessary for maintaining life and is used in all cells of the body, it is an essential component of cell membranes and is a precursor of steroid hormone; it helps to absorb and digest fat and plays an important role in the formation of vitamin D. However, higher cholesterol concentrations have long been associated with a higher risk of cardiovascular diseases (CVD). If there is too much serum cholesterol, it tends to accumulate on the walls of the blood vessels, forming plaque and narrowing the blood vessels, which in some cases could promote heart attack, stroke and blood clotting (Rahkovsky and Gregory, 2013). Therefore, consumers are increasingly concerned about excessive intakes of cholesterol and it was recommended that the total cholesterol intake should be less than 300 mg/day (Brown, 1990). Egg intake increases LDL- and HDL cholesterol in body, but this change is relatively small. One egg per day in a diet was not related to heart disease (McNamara, 2013). Most healthy people were not at risk of CVD or increased mortality when they eat eggs. However, diabetic patients were at an increased risk of CVD because of a small change in circulating cholesterol after egg intake (Shin et al., 2013).

From ancient times, eggs have been an important source of high quality protein, other beneficial nutrients, and also a primary source of dietary cholesterol. Eggs from all species of poultry consists of 52%–58% egg white, 32%–35% egg yolk and 9%–14% shell, and contain about 200–250 mg cholesterol (Griffin, 1992; Mine, 2008). Catering to the consumers’ demands, food companies attempt to reduce cholesterol in a wide variety of food, and they have investigated different approaches to reduce cholesterol in eggs, such as hypocholesterolemic agent administration (Hargis, 1988; Griffin, 1992) extraction with solvents (Melnick, 1971; Merchant et al., 1991) or oils (Frioriti et al., 1978) and supercritical fluid extraction (Haberstroh and Morris, 1991). The removal of cholesterol by absorption with β-CD is an alternative approach (Smith et al., 1995) used to produce cholesterol-reduced egg products (80% cholesterol free), based on a patent of reported by Cully and Vollbrecht (1990), that was marketed briefly in the US.

According to previous study (Kim et al., 2004), it was reported that the crosslinked β-CD made with adipic acid exhibited higher cholesterol removal than β-CD in milk, it was also reported that the β-CD removed over 90% of cholesterol from egg yolk diluted with water (1:1) and that the β-CD could be recovered and recycled for further use (Jung et al., 2005). Therefore, this method could be applied in industrial food processing. But the separation of egg components in the food industry is a complex process which sometimes involves undesirable property changes. Therefore, the objective of this study was to optimize cholesterol removal from whole egg by crosslinked β-CD.

MATERIALS AND METHODS

Materials

Eggs were purchased from a retail store with the average size of 62.67±0.25 g and powdered crosslinked β-CD was obtained from MSC Co. (Yangsan, Korea). Hexane (purity 95%), potassium hydroxide (purity 95%) and ethanol (purity 95%) were obtained from Samchun Chemical Co. Ltd. (Pyongtack, Korea). Cholesterol (purity 99%) was purchased from Sigma Chemical Co. (St Louis, MO, USA).

Proximate composition

The compositions of whole egg were analyzed for water, crude protein, total carbohydrate, total lipid and ash according to the method of Association of Official Analytical Chemists (AOAC, 2000).

Cholesterol removal from whole egg

After removing the egg shell, whole eggs were mixed and sieved. Whole egg (100 g) was placed in 300 mL beaker and crosslinked β-CD was added to give final concentrations of 10%, 15%, 20%, 25%, and 30% (w/v). The mixture was stirred at various speeds (400, 600, 800, and 1,200 rpm) with a blender (Tops; Misung Co., Seoul, Korea). This process was performed in a temperature controlled water bath at different mixing temperatures (30°C, 35°C, 40°C, 45°C, and 50°C) for different times (20, 30, 40, 50, and 60 min). The mixture was centrifuged (HMR-220IV; hanil Industrial Co., Seoul, Korea) at different speeds (2,210, 2,810, 3,440, 4,140, and 4,900×g) for 10 min. All treatments were repeated 3 times.

Extraction and quantification of cholesterol from whole egg

The extraction of cholesterol was achieved using the modified method of Adams et al. (1986). Crosslinking of β-CD was made according to the method of Han et al. (2007). One gram of the crosslinked β-CD-treated whole egg was placed in screw-capped glass tube (15×180 mm). The sample was saponified at 60°C for 30 min with 5 mL of 2 M ethanolic potassium hydroxide solution. After cooling to room temperature, cholesterol was extracted with 5 mL of hexane. The process was repeated four times. The hexane layer was transferred to a round bottomed flask and dried under vacuum. The extract was re-dissolved in 1 mL of hexane.

Total cholesterol was measured on a silica fused capillary column (HP-1, 25 m×0.32 mm I.D.×0.17 μm thickness) using a Donam gas chromatography (Seoul, Korea) equipped with a flame ionization detector. The injector and detector temperatures were 270°C and 300°C, respectively. The oven temperature was programmed to increase from 200°C to 300°C at 10°C/min and then was maintained for 20 min. Nitrogen was used as carrier gas at a flow rate of 2 mL/min with a split ratio of 1:50. The injected sample volume was 2 μL. Quantification of cholesterol was done by comparing the peak area with the standard curve. The percentage of cholesterol reduction was calculated as follows:

Cholesterol reduction (%)=100-[theamount of cholesterol in the crosslinkedβ-CD-treated whole egg×100/the amount ofcholesterol in the untreated whole egg(control)]

Yield of recyclable crosslinked β-CD

The cholesterol-entrapped crosslinked β-CD was mixed with ethanol in a conical flask (500 mL) at 100 rpm stirring speed using a hot plate magnetic stirrer (Misung Scientific Co., Ltd, Seoul, Korea) for 1 h at boiling point, and the ratio of compound to solvent was 1:4. The sample was then cooled to room temperature and centrifuged at 6,300×g for 5 min. The precipitated crosslinked β-CD was dried at 60°C in dry oven for 6 h and reused for this recycling study. The recyclable yields of crosslinked β-CD were calculated as follows:

Yield (%)=(Recoveredamount of crosslinked β-CD after recycle/Initial amount of β-CD)×100

Statistical analysis

Data from each experiment were analyzed using SAS version 9.0 (SAS Institute Inc., 2002). An ANOVA was performed by the general linear models procedure to determine between the samples. Means were compared by using Duncan’s method. A significance level was set at p<0.05.

RESULTS

Proximate composition of whole egg

The proximate composition of whole egg was water 74.81±0.06 mL, crude protein 13.52±0.32 g, total carbohydrate 0.67±0.12 g, total lipid 8.92±0.12 g, ash 0.79±0.26 g per 100 gram and cholesterol 448±0.25 mg per 100 g.

Effect of crosslinked β-CD concentrations

The various concentrations of the crosslinked β-CD (10%, 15%, 20%, 25%, and 30%; W/V) were applied into whole egg to optimize cholesterol removal as shown in Table 1. The concentrations of the β-CD removed cholesterol from 80.08% to 91.88% when mixed at 40°C for 30 min with 800 rpm. There was no significant difference between 25% and 30%, and cholesterol removals were 91.88% and 90.21% (p>0.05), respectively. Therefore, the result indicated that 25% crosslinked β-CD may be a suitable amount to remove cholesterol effectively in whole egg.

Effect of various crosslinked β-cyclodextrin concentrations on cholesterol removal from whole egg1

Effect of mixing temperature

The effect of cholesterol removal from whole egg by the crosslinked β-CD with the various mixing temperatures (30°C, 35°C, 40°C, 45°C, and 50°C) is shown in Table 2. The different mixing temperatures had an effect on cholesterol removals from 87.85% to 90.96% when treated with 25% crosslinked β-CD at 800 rpm mixing speed for 30 min with 2,810×g centrifugal speed. Differences of cholesterol removal were not significant among 40°C, 45°C, and 50°C (p>0.05), and the cholesterol removals were in the range of 89.54% to 90.96%. Therefore, this study concluded that 40°C is the optimal temperature for cholesterol removal from whole egg.

Effect of various mixing temperatures on cholesterol removal from whole egg using crosslinked β-cyclodextrin1

Effect of mixing time

The effect of various mixing times (20, 30, 40, 50, and 60 min) used to optimize cholesterol removal by the crosslinked β-CD are shown in Table 3. In this study, a significantly greater (p<0.05) cholesterol removal of 93.44% was observed at the 30 min mixing time. However, other mixing times also achieved over 90% cholesterol removal from 25% crosslinked β-CD at 40°C with 800 rpm mixing speed and 2,810×g centrifugal speed. Therefore, the result concluded that the optimum mixing time is 30 min.

Effect of various mixing times on cholesterol removal from whole egg using crosslinked β-cyclodextrin1

Effect of mixing speed

The effect of mixing speeds (400, 600, 800, 1,000, and 1,200 rpm) on cholesterol removal efficiency is shown in Table 4. The cholesterol removal ranged from 88.95% to 93.43% when treated with 25% cross linked β-CD at 40°C for 30 min with 2,810×g centrifugal speed. There was no significant difference between 600 and 800 rpm, and cholesterol removal was 93.33% and 93.43%, respectively (p<0.05). Over 800 rpm, the cholesterol removal decreased gradually to 88.95% at 1,200 rpm. Therefore, the result indicated that 800rpm could be optimal mixing speed.

Effect of various mixing speeds on cholesterol removal from whole egg using crosslinked β-cyclodextrin1

Effect of centrifugal speed

The various centrifugal speeds (2,210, 2,810, 3,440, 4,140% and 4,900×g) were selected to optimize cholesterol removal as shown in Table 5. The cholesterol removal increased up to 92.76% when centrifugal speed increased to 2,810×g. However, the cholesterol removal decreased significantly at 3,440×g (p<0.05). Cholesterol removal decreased to 86% when the centrifugal speed was higher than 3,440×g. Therefore, this result showed that 2,810×g might be the most effective centrifugal speed.

Effect of various centrifugal speeds on cholesterol removal from whole egg using crosslinked β-cyclodextrin1

Recyclable yield of crosslinked β-CD

The crosslinked β-CD for recycling was applied to whole egg five times repeatedly and the yield of the crosslinked β-CD is shown in Figure 1. The recyclable yield of the crosslinked β-CD was found to be between 87.66% and 86.6% from one and three time uses with no significant difference (p>0.05). However, a slight increase was shown in fourth and fifth time uses as 92.03% and 96.74%, respectively. The yields of the crosslinked β-CD in fourth and fifth recycles were even more than the yield following its initial use (93.69%) to remove cholesterol from whole eggs.

Figure 1

The efficiency of recycled crosslinked β-cyclodextrin on cholesterol removal from whole egg. Conditions for cholesterol removal; crosslinked β-CD; 25%, mixing temperature; 40°C, mixing time; 30 min, mixing speed; 800 rpm, centrifugal speed; 2,810×g. All samples were repeated 3 times. a,b Values with different superscripts within the same column differ significantly (p<0.05).

Cholesterol removal efficiency of recyclable yield of crosslinked β-CD

After the optimization of cholesterol removal from whole egg, the cholesterol removal efficiency of the crosslinked β-CD in whole egg was examined at 5 repeated times and is presented in Figure 2. Higher cholesterol removal was found in the range of 86.87% to 83.75% when the crosslinked β-CD was used for three times, but cholesterol removal significantly decreased to 70.94% by the fifth recycle (p<0.05).

Figure 2

Cholesterol removal using crosslinked β-cyclodextrin with repeated recycling in whole egg. Conditions for cholesterol removal; crosslinked β-CD; 25%, mixing temperature; 40°C, mixing time; 30 min, mixing speed; 800 rpm, centrifugal speed; 2,810×g. All samples were repeated 3 times. a–e Values with different superscripts within the same column differ significantly (p<0.05).

DISCUSSION

Several studies have investigated the optimum condition for removing cholesterol from different food products including milk (Kim et al., 2004), cream (Han et al., 2007), cod liver oil (Chang et al., 2010), lard (Kim et al., 2007) and also egg yolk (Jung et al., 2005). In the present study, the optimum conditions of five different factors (crosslinked β-CD concentration, mixing temperature, mixing time, mixing speed and centrifugal speed) were examined in cholesterol removal from whole eggs using crosslinked β-CD. It was found that 25% crosslinked β-CD was a sufficient amount to remove cholesterol effectively from whole egg. The percentage of cholesterol removal decreased when 30% crosslinked β-CD was used, because an excess of β-CD could compete with each other to bind to cholesterol molecules (Micich, 1990). It was also reported that cholesterol-β-CD complex in egg yolk became unstable above 40°C, when 80% of cholesterol dissociated from β-CD (Kwak et al., 2001). According to the results, it can be concluded that the cholesterol removal showed a declining trend when mixing temperature was set higher than the optimum temperature (40°C). In addition, the decrease in cholesterol removal after 30 min of mixing time could be related to instability of an inclusive cholesterol-β-CD compound over a longer mixing time (Chang et al., 2010). A study (Jung et al., 2005) showed that the removal was in the range of 75.9% to 91.6% when egg yolk was mixed with 20% crosslinked β-CD at 40°C for 30 min and that a centrifugal speed at 2,210 to 5,470×g had no significant effect on removal rate, therefore, they stated that mixing and centrifugal speeds may not play an important role on cholesterol removal rate from egg yolk. This result agrees with the present study showing over 85% cholesterol removal from whole egg with different mixing and centrifugal speeds, so it can be assumed that the mixing speed and centrifugal speed may not be the important factors in this process. Thereby, the optimum condition for cholesterol removal could vary with different food products.

In whole eggs, egg white consists of a solution of about 10% protein, containing more than 40 different kinds of proteins. Egg yolk consists of nearly 17% protein (Mine, 2007). A review has described studies of the binding of cyclodextrin to protein, and almost all studies have identified amino acid residues as the main structural element interacting with cyclodextrin. So, it can be assumed that the crosslinked β-CD, which is only a product of a crosslinking reaction between C-2 position of β-CD and one of the carboxyl groups of the crosslinking agent (Kwak et al., 2011), could combine with cholesterol from egg yolk as well as bind to amino acid residues from egg protein. If it is so, it can explain why the cholesterol removal efficiency of the crosslinked β-CD for recycling is low in present study. By contrast, a similar study stated that over 80% cholesterol removal rate from egg yolk diluted with water was obtained when crosslinked β-CD was reused up to 8 times used with no significant difference(p<0.05) between each removal (Jung et al., 2005). In the present study, as the number of repetitive uses of the crosslinked β-CD was increased, the β-CD bound to more egg protein from whole egg; as a result, cholesterol removal ability of crosslinked β-CD was reduced. Therefore, the cholesterol removal efficiency of crosslinked β-CD decreased significantly at the last two recycles, and the recyclable yield of the crosslinked β-CD also increased accordingly when the β-CD was used many times.

In conclusion, this study indicated that the optimum conditions of cholesterol removal were 25% crosslinked β-CD, 40°C mixing temperature, 30 min mixing time, 1,200 rpm mixing speed and 2,810×g centrifugal speed. Moreover, the crosslinked β-CD could not be applied into whole egg in the cholesterol removal process with an effective recycling. Further study about the binding of the crosslinked β-CD to components in egg will be necessary in future.

ACKNOWLEDGEMENTS

This study was supported by Ministry for Food, Agriculture, Forestry and Fisheries funded by the Korean Government (311029-03-2-HD110).

References

Adams ML, Sullivan DM, Simth RL, Richter EF. 1986;Evaluation of direct saponification method for determination of cholesterol in meats. J Assoc Offic Anal Chem 69:844–846.
AOAC. 2000. Official Methods of Analysis 10th ednth ed. Association of Official Analytical Chemists. Washington, DC, USA:
Brown WV. 1990;Dietary recommendation to prevent coronary heart disease. Ann NY Acad Sci 598:376–388.
Chang YH, Lee JE, Kwak HS. 2010;Optimization of the condition for removing cholesterol from cod liver oil by β-cyclodextrin crosslinked with adipic acid. J Am Oil Chem Soc 87:803–808.
Cully J, Vollbrecht HR. 1990. Process for the removal of β-cyclodextrin from egg yolk US Patent NO 5292546.
Frioriti JA, Rex JS, Clifford H. 1978. Low cholesterol egg product and process US Patent No. 4103040.
Griffin HD. 1992;Manipulation of egg yolk cholesterol: A physiologist’s view. World’s Poult Sci J 48:101–112.
Haberstroh C, Morris CE. 1991. Fat and cholesterol reduced foods 1st ednth ed. Gulf Publ. Co. Houston TX, USA:
Han EM, Kim SH, Ahn J, Kwak HS. 2007;Optimization cholesterol removal from cream using β-cyclodextrin crosslinked with adipic acid. Int J Dairy Technol 60:31–36.
Hargis PS. 1988;Modifying egg yolk cholesterol - A review. World’s Poult Sci J 44:17–29.
Jung TH, Park HS, Kwak HS. 2005;Optimization of cholesterol removal by crosslinked β-cyclodextrin in egg yolk. Food Sci Biotechnol 14:793–797.
Kim SH, Kim HY, Kwak HS. 2007;Cholesterol removal from lard with crosslinked β-cyclodextrin. Asian-Aust J Anim Sci 20:1468–1472.
Kim SH, Ahn J, Kwak HS. 2004;Crosslinking of β-cyclodextrin on cholesterol removal from milk. Arch Pharm Res 27:1183–1187.
Kwak HS, Suh HM, Ahn J, Kwon HJ. 2001;Optimization of β-cyclodextrin recycling process for cholesterol removal in cream. Asian-Aust J Anim Sci 14:548–552.
Kwak HS, Lee JE, Chang YH. 2011;Structural characterization of β-cyclodextrin crosslinked by adipic acid. Int J Food Sci Tech 46:1323–1328.
McNamara DJ. 2000;The impact of egg limitations on coronary heart disease risk: Do the Numbers Add up? J Am Coll Nutr 19:540S–548S.
Melnick D. 1971. Low cholesterol dried egg yolk and process U S Patent No. 3563765.
Merchant ZM, Anikumar GG, Krishnamurthy RG. 1991. Functional decholesterolized egg yolks US Patent No. 5037661.
Micich TJ. 1990;Behavior of polymer supported digitonin with cholesterol in the absence and presence of butter oil. J Agric Food Chem 38:1839–1843.
Mine Y. 2008. Egg Bioscience and Biotechnology 1st ednth ed. John Wiley and Sons, Inc. Hoboken, NJ, USA:
Rahkovsky I, Gregory CA. 2013;Food prices and blood cholesterol. Econ Hum Biol 11:95–107.
SAS. 2002. User’s Guide: Statistics Version 9 Edn. SAS Institute Inc. Cary, NC, USA:
Shin JY, Xun P, Nakamura Y, He K. 2013;Egg consumption in relation to risk of cardiovascular disease and diabetes: A systematic review and mata-analysis. Am J Clin Nutr 98:146–159.
Smith DM, Awad AC, Bennink MR, Gill JL. 1995;Cholesterol reduction in liquid egg yolk using β-cyclodextrin. J Food Sci 60:691–694.

Article information Continued

Figure 1

The efficiency of recycled crosslinked β-cyclodextrin on cholesterol removal from whole egg. Conditions for cholesterol removal; crosslinked β-CD; 25%, mixing temperature; 40°C, mixing time; 30 min, mixing speed; 800 rpm, centrifugal speed; 2,810×g. All samples were repeated 3 times. a,b Values with different superscripts within the same column differ significantly (p<0.05).

Figure 2

Cholesterol removal using crosslinked β-cyclodextrin with repeated recycling in whole egg. Conditions for cholesterol removal; crosslinked β-CD; 25%, mixing temperature; 40°C, mixing time; 30 min, mixing speed; 800 rpm, centrifugal speed; 2,810×g. All samples were repeated 3 times. a–e Values with different superscripts within the same column differ significantly (p<0.05).

Table 1

Effect of various crosslinked β-cyclodextrin concentrations on cholesterol removal from whole egg1

Concentration of crosslinked β-CD (%) Cholesterol removal (%)
10 80.0±0.3d
15 87.2±2.5c
20 88.5±2.1bc
25 91.9±0.6a
30 90.2±0.2ab
1

Conditions for cholesterol removal; mixing temperature; 40°C, mixing time; 30 min, mixing speed; 800 rpm, centrifugal speed; 2,810×g. All samples were repeated 3 times.

a–d

Values with different superscripts within the same column differ significantly (p<0.05).

Table 2

Effect of various mixing temperatures on cholesterol removal from whole egg using crosslinked β-cyclodextrin1

Mixing temperature (°C) Cholesterol removal (%)
30 87.85±5.86c
35 88.60±4.75c
40 90.96±3.43a
45 89.88±4.59ab
50 89.54±6.92abc
1

Conditions for cholesterol removal; crosslinked β-CD; 25%, mixing time; 30 min, mixing speed; 800 rpm, centrifugal speed; 2,810×g. All samples were repeated 3 times.

a–c

Values with different superscripts within the same column differ significantly (p<0.05).

Table 3

Effect of various mixing times on cholesterol removal from whole egg using crosslinked β-cyclodextrin1

Mixing time (min) Cholesterol removal (%)
20 90.74±3.90b
30 93.44±2.26a
40 90.76±0.38b
50 90.46±0.92b
60 90.02±0.57b
1

Conditions for cholesterol removal; crosslinked β-CD; 25%, mixing temperature; 40°C, mixing speed; 800 rpm, centrifugal speed; 2,810×g. All samples were repeated 3 times.

a,b

Values with different superscripts within the same column differ significantly (p<0.05).

Table 4

Effect of various mixing speeds on cholesterol removal from whole egg using crosslinked β-cyclodextrin1

Mixing speed (rpm) Cholesterol removal (%)
400 92.4±0.3a
600 93.3±1.5a
800 93.4±0.5a
1,000 90.0±0.4b
1,200 89.0±0.4b
1

Conditions for cholesterol removal; crosslinked β-CD; 25%, mixing temperature; 40°C, mixing time; 30 min, centrifugal speed; 2,810×g All samples were repeated 3 times.

a,b

Values with different superscripts within the same column differ significantly (p<0.05).

Table 5

Effect of various centrifugal speeds on cholesterol removal from whole egg using crosslinked β-cyclodextrin1

Centrifugal speed (×g) Cholesterol removal (%)
2,210 92.5±1.2a
2,810 92.8±1.1a
3,440 87.0±4.2b
4,140 87.0±0.5b
4,900 86.5±10.b
1

Conditions for cholesterol removal; crosslinked β-CD; 25%, mixing temperature; 40°C, mixing time; 30 min, mixing speed; 800 rpm. All samples were repeated 3 times.

a,b

Values with different superscripts within the same column differ significantly (p<0.05).